Climate Vulnerability : Drought
Farmers cultivating transplanted rice in irrigated and rainfed areas are increasingly faced with water shortages due to deficit rainfall, declining groundwater table due to insufficient recharge, late and limited release of irrigation water from canals or poor inflows into tanks. Land preparation for nursery and main field require copious amounts of water and involve labour for nursery raising of seedlings and subsequent transplanting. Water shortage at the transplanting time leads to delay and use of over aged seedlings with limited tillering capacity. Farmers' face these situations during kharif season in NICRA villages in Saran, Aurangabad, Jehanabad (Bihar), Koderma (Jharkhand) and Gondia (Maharashtra); and during both kharif and rabi seasons in Khammam (Telangana), West Godavari and Srikakulam (Andhra Pradesh). In Muttar village located in the Kuttanad region of Allapuzha, Kerala farmers' practice broadcasting paddy seed in the “Puncha” crop (November – March), which results in low productivity. Water and labour saving technique of drum seeding of rice is a feasible option to farmers in these areas.
Resilient practice / technology
Drum seeding technique involves direct seeding of pre-germinated paddy seeds in drums made up of fibre material to dispense seeds evenly in lines spaced at 20 cm apart in puddled and levelled fields. About 35 to 40 kg paddy seed/ha is soaked overnight in water and allowed to sprout. Care should be taken not to delay sowing as seeds with long shoot growth are not suitable for drum seeding. The sprouted seed is air-dried in shade briefly (
Impact of drum seeding technique in paddy
Rice is the major crop in Nacharam village in Khammam district. Farmers cultivate long duration (145–160 days) rice varieties like BPT-5204, WGL-482 and JGL-18047. These varieties are usually sown in the nursery in mid June and transplanted in mid-July. Farmers use a seed rate of 75 kg /ha and face serious shortage of labour for manual rice transplanting. Initially in 2012, direct sowing with drum seeder was introduced to five progressive farmers in the village in 3 ha area and sowing was taken up during 2nd and 3rd week of July. Cost of cultivation came down by Rs 10000/ha. Yield obtained ranged between 42 to 54 q/ha compared to 35 to 46 q/ha with transplanted paddy. Increase in grain yield ranged from 13 to 28%. In 2013, farmers took up direct seeding both in kharif and rabi seasons. Drum seeded paddy was applied four irrigations (two less than transplanted paddy). Advantage in net income due to drum seeding ranged from Rs 13000-14000/ha in both the seasons and B:C ratio was higher ( 2.3 to 2.9) with drum seeding compared to transplanted paddy (1.5 to 2.0).
Farmers in Matsyapuri village, West Godavari district cultivate paddy in tail end areas during rabi season. These farmers are forced to go for delayed planting due to late release of canal water. Farmers took up direct sowing with drum seeder to overcome this situation. Initially six farmers came forward and drum seeding was practiced in 9.5 acres during rabi 2012-13. Cost of cultivation was reduced by Rs 10000/ha compared to the transplanting method. Crop yield in direct sown paddy was 4% higher and benefit cost ratio was also higher (2.3) with less water compared to transplanting method. More farmers in the village came forward to take up drum seeded paddy in rabi 2013-14 in 50 acres. The duration of crop was reduced by 7-9 days in direct sowing compared to transplanting method. This helped in saving the crop from excess rains during the month of May 2014 as the harvesting was completed before the rains.
In Muttar village, Alapuzha district, Kerala farmers take up the 'Puncha' paddy by broadcasting seed in the low lying fields after receding of flood waters as is the general practice in the Kuttanad region. Farmers took up line sowing of paddy (20 cm x 10 cm) with eight row drum seeder. One hectare could be covered in 10 hours time. Drum seeding required less quantity of seeds (30 kg/ha) compared to broadcasting (100 kg/ha). Apart from saving in seed, fertilizer to the extent of 30% could be saved due to soil test based nutrient application along with application of lime/dolomite to counter the soil acidity problem in the village. The results of the demonstrations in three consecutive years in different 'pada sekharams' were encouraging. Biometric observations showed better growth of crop, more number of productive tillers and higher grain number in panicles. While cost of cultivation was reduced by about Rs 2900 to 6000/ha, net income ranged from Rs 13000 to 24000/ha in different years. Benefit: cost ratio ranged between 2.2 to 3.0 with drum seeding and 1.6 to 2.5 with broadcasting. Farmers in Muttar village are now willing to purchase drum seeders in view of the benefits demonstrated in their fields. The integrated crop management practices followed in the paddy fields sown with drum seeder will go a long way in reducing GHG emissions and environmental pollution in this fragile agro-ecosystem in the Kuttanad region.
Scope for upscaling
Under NICRA, drum seeding of paddy was demonstrated in 194 ha covering 367 farmers in Aurangabad, Jehanabad, Saran (Bihar), Gonda, Sonbhadra (Uttar Pradesh), Khammam, Nalgonda (Telengana), West Godavari, Anantapur, Kurnool, Srikakulam (Andhra Pradesh) and Alapuzha (Kerala) with an average yield increase of 9 to 29 % and benefit cost ratio of 1.9 to 2.9 compared to current practice of transplanting. There is scope for wider adoption of drum seeding in these states under the National Mission on Sustainable Agriculture.
Source: Smart practices and Technologies for Climate Resilient Agriculture